ISO certification gas steam boiler for hotel heating

Industrial boiler market share rise, to the current trend of energy-saving industry, industrial boilers are mainly used in metallurgy, chemicals, coke, cement, paper, shipbuilding and other industries, mainly through heating boiler, steam production unit each to provide the required or hot water. Different transformation and power industry, industrial boilers since often small cell capacity, installed at the rear end of expensive desulphurization and denitrification apparatus is very uneconomical, so the transformation of coal will be the main alternative route, the coal gas, biomass fuels, cleaning three coal technology route, clean coal will assume the main task. By the end of 2011, the total industrial boilers reach 58.5-60 million units, of which the boiler, the capacity accounted for more than 80% of coal-fired boilers, boiler capacity is less than the number of 35 tons / hour of 96% of the total, while 10 accounting tons / hour up to 80%. Meanwhile, the average thermal efficiency of industrial boilers only 60%, 20-25% lower than in other countries. The country's industrial kilns more than 160,000, concentrated in building materials, metallurgy, chemicals and ceramics and other industries, the annual coal consumption of 300 million tons. The average heating furnace thermal efficiency of only 40%, 10-30% lower than in other countries. A wide range of large industrial boilers in China, the average capacity of small and dominated by coal. Although China's coal-fired industrial boiler design productivity gap compared with foreign small, but the actual operating efficiency of only 65%, 10% -15% lower than the advanced level. Industrial boilers with maximum downstream chemical materials and chemical products manufacturing market size, non-ferrous metal smelting and rolling processing industry, petrochemical industry market size is large, in addition, the market size paper and shipbuilding industries is relatively small, moderate growth in the cement manufacturing industry . Overall, the future of Chinese boiler market demand is still the main metallurgy, chemical and petrochemical three coking industry, and paper, cement and other industries demand is relatively weak, shipbuilding recession has not slowed. Industrial boilers, especially coal-fired industrial boilers for energy saving is important for achieving the overall goal of energy conservation.

Recently, Shaanxi Province issued a notice "issued four Battle 2019 program of work". Programs that: improve the mechanism of heating prices, heating prices reasonable development of clean, green electricity implement ultra-low emissions coal-fired power plants, a comprehensive clean canceled preferential tariff class of high energy-consuming industries unreasonable prices and other preferential policies. Off Area ban coal stove, substantially eliminated cogeneration heating pipe network coverage in the range of coal heated oven (furnace).

According to focus on the use of coal and clean use of principles, focusing on reduction of non-coal for electricity, increase the proportion of electricity from coal. Increase Condensing units and cogeneration units technological transformation efforts, speed up the heating pipe network construction, fully release and improve the heating capacity, eliminate coal-fired boilers and scattered inside the pipe network coverage. Actively implement alternative heat source, deadline for shutting down the Guanzhong area below 100,000 kilowatts thermoelectric ratio does not meet the national standard or alternative heat source thermal units. Optimal operation mode cogeneration units, strictly implement the "hot set electricity."

Environmental Protection measures of Environmental Protection BoilerEnergy-saving and high-efficiency atmospheric pressure environmental protection boiler can convert black smoke into gas combustion and save coal consumption. The atmospheric pressure environmental protection boiler has double-layer grate and two combustors. If the coal in the upper combustion chamber does not burn well, it can continue to burn in the lower combustor. At the same time, the primary air, secondary air, fuel can give enough oxygen to fully burn. According to the comparison of users' field use, it can save about 30% and 50% compared with the similar big bituminous coal boiler and briquette boiler, etc. The environmental protection standard atmospheric pressure environmental protection boiler can burn all kinds of bituminous coal, and can turn the black smoke into the gas combustion rapidly, the smoke pipe will not emit black smoke, purify the fine dust and the oxygen Sulfur, after monitoring, all indicators meet the national environmental standards. The steel plate of the atmospheric pressure boiler of reliable quality is made of the national standard steel plate, the material is Q235A, Q235B, the international seamless steel pipe, the material is 20, GB3087, GB8163, the production material and the manufacture craft are carried out strictly according to the national standard. After testing, each index also reached the national standard. The operation safety atmospheric pressure environmental protection boiler structure is very compact, the occupation area is also small, the upper temperature is fast, is no pressure operation, safe and reliable. Environmental protection pressure iso certification steam boiler for hotel heating equipped with a number of safety protection devices, exceeding the pressure, safety valve automatically opened Exhaust steam to ensure safe operation.

Fuel gas control step and the blowing process air volume of the total fuel gas iso certification steam boiler for hotel heating steam boiler is achieved by adjusting a liquid coupling scoop blower. Organization fuel gas steam boiler combustion, is to make a, air pressure, air flow of secondary air with the good. Adjusting the amount of primary air should meet it carries the fuel into the furnace ignition of volatile oxygen required, and to maintain a certain speed, and without clogging the fuel discharge pipe of the jet having a certain rigidity. Primary air volume is too large and too small, the wind speed is too high and too low, should be avoided. In addition to adjusting the secondary air of combustion of the fuel should ensure that the oxygen demand, but must maintain a certain wind speed and primary air is mixed with the master time should have a strong stirring and mixing coke penetrate "the Gray" kinetic , which requires the case may be, each layer of the secondary air flow rate, in order to achieve stable combustion and flue gas excess oxygen appropriate destination. Fuel gas steam boiler, secondary air with what is better? Primary air volume air volume of the total share is called the primary air rate. A small air fraction, pulverized coal is heated to at least the heat required for the ignition point, fire faster, but the amount of primary air to satisfy the principle of combustion of volatiles. Secondary air mixed with the primary air time to the right. If it is mixed before ignition, means an increase in the amount of primary air, so that the ignition delay; hypoxia combustion secondary air if mixed will make late after ignition; if secondary air is mixed all at one position, since the secondary air temperature well below flame temperature, the flame temperature decreases, the combustion slows down, causing the fire. Therefore, the secondary air mixed with fuel should be based on the nature of the combustion zone as required timely sent, so that the combustion of oxygen, and will not reduce the flame temperature to ensure complete combustion and ignition stability. One or two wind speed with what is better? Fuel gas steam boiler once the wind speed is high, the fuel gas stream will catch fire in places far away from the burner, the ignition point postponed; once the wind speed is too low, it will cause a blocked ducts, and ignition point is too far forward, the burner will burn , but also easy to coke near the burner.

ISO certification gas steam boiler for hotel heating Related Information

biomass boiler on sale - China quality biomass boiler

10 ton pressure 1.25 MPa 13 bar 13 kg water tube biomass boiler, double drum dual drum biomass fired steam boiler Price : $10,000 - $50,000 / Set Min.order : 1 Sets

Get a Quote

QINGDAO HAMMER INDUSTRIES CO., LTD. - Contact

ISO 9001, ISO 9000, ISO 20000, QC 080000 Vertical Fuel/Gas/Hot Water/Steam Boiler, Wns Natural Gas and Diesel Fired Centrial Heating System Hot Water Boiler for Hotel and Greenhouse and so on. Contact Supplier Company Favorites Company Favorites. Gold Member

Get a Quote

Gas Fired Steam Boiler on sales - Quality Gas Fired

Gas Fired Steam Boiler. Quality Best 500 - 20000kg/h Oil Gas Fired Steam Boiler With Original Riello Burner. WNS 15t/h Best Service and Technical Support Industrial Gas Fired Steam Boiler. 5 ton industrial gas diesel oil fired steam boiler for pharmaceutical industry. Oil Fired Steam Boiler

Get a Quote

LDR/WDR Electric Steam Boiler,Electric Heating Boiler

2020-1-18 · LDR/WDR electric steam boiler makes the electrical control cabinet separate from boiler body to avoid affecting the boilers working life when the electrical elements become aging. The electrical heated tube can be used for about 20000 hours; its thermal efficiency could almost be 99% and will not release NOX to the air, it is environmental.

Get a Quote

Mud/Water Drum Boiler Maintenance Parts for

Mud/Water Drum Boiler Maintenance Parts for Industrial/Commercial Boiler with SGS, Find Details about Boiler Steam Drum, Steam Drum from Mud/Water Drum Boiler Maintenance Parts for Industrial/Commercial Boiler with SGS - Jinan Yuanda Power Equipment Co., Ltd.

Get a Quote

China Power Boiler Burner for Coal and Diesel Oil

China Power Boiler Burner for Coal and Diesel Oil Fired Boiler Furnace, Find details about China Gas Burner, Oil Burner from Power Boiler Burner for Coal and Diesel Oil Fired Boiler Furnace - Jinan Yuanda Power Equipment Co., Ltd.

Get a Quote

China Exhaust Gas Boiler manufacturer, Waste Heat

Exhaust Gas Boiler, Waste Heat Boiler, Marine Boiler manufacturer / supplier in China, offering High Frequency Welded Stainless Steel Spiral Fin Tubes Carbon Steel Spiral Finned Tubes Factory Provided, Factory Supply Pin Fine Tubes Marine Boiler Tubes Heat Exchange Tube Parts with Lr /BV/ABS/CCC Certificate, Small Size Industrial Used Oil Fired Steam Boiler Steam Heat Exchanger and so on.

Get a Quote

Industrial Natural Gas Fired Steam Boiler

2020-1-18 · The industrial natural gas fired steam boiler is a kind of safe and high efficiency heating equipment with full automatic control system.As the natural gas boiler has the characteristics of compact structure, safe operation, convenient installation, low pollution and low noise.

Get a Quote

LDR/WDR Electric Steam Boiler,Electric Heating Boiler

2020-1-18 · LDR/WDR electric steam boiler makes the electrical control cabinet separate from boiler body to avoid affecting the boilers working life when the electrical elements become aging. The electrical heated tube can be used for about 20000 hours; its thermal efficiency could almost be 99% and will not release NOX to the air, it is environmental.

Get a Quote

boiler foundation design energy-saving boiler

2018-8-1 · boiler foundation design. 2016-06-02 Published by: Cindy 0 . As a 70 years experience of boiler manufacturer, ZG provide various type of energy-saving boilers, like gas fired boiler,oil fired boiler, biomass fired boiler, CFB boiler, industrial autoclave, as well as chain grate boiler for customers to chose.

Get a Quote

Iso Boiler, China Iso Boiler Suppliers Directory on

China Iso Boiler, Iso Boiler from China Supplier - Find Variety Iso Boiler from industrial boiler,steam boiler,power boiler, Boilers Suppliers Located in China, Buy Iso Boiler Made in China on Alibaba.com

Get a Quote

Industrial Horizontal Type Fire Tube Oil/Natural Gas

About. FANGKUAI is founded in 1998, which is a clean fuel boiler enterprise integrating R&D, manufacturing, sales and service. In the past 20 years of development and innovation, the company has grown into a global enterprise, and its products have been exported to more than 80 countries including Russia, Mongolia and Thailand, and have established long-lasting cooperative relations with local

Get a Quote

Electric Steam Boiler, Electric Steam Boiler direct from

Electric Steam Boiler from Shanghai Yano Boiler Manufacturing Co., Ltd.. Search High Quality Electric Steam Boiler Manufacturing and Exporting supplier on Alibaba.com.

Get a Quote

Steam Boiler, Hot water Boiler - Alibaba.com

Xinxiang Xinda Boiler Container Co., Ltd., Experts in Manufacturing and Exporting Steam Boiler, Hot water Boiler and 1643 more Products. A Verified CN Gold Supplier on Alibaba.com.

Get a Quote

China Gas Boiler manufacturer, Steam Boiler, Coal

Gas Boiler, Steam Boiler, Coal Boiler manufacturer / supplier in China, offering Columbia 1t 2t 4t 6t 8t Automatic Solid Fuel Boilers, Fully Equipped 10t/H Capacity Horizontal Type Wood Pellet Boiler, High Quality Packaged Coal Boiler Automatic Steam Boiler on Coal and so on.

Get a Quote

Related Information

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!