made in china coal fired steam boiler

After the gas hot water boiler hot water boiler vaporization emergency 1. Vaporization handler circulating pump stops abnormally pump failure caused by: ① blower stops running immediately. ② immediately open the door, take measures to pressure the fire, lift the chute gate, cutting off the supply of coal grate. ③ In the case of boiler pressure not greater than 0.6MPa (600KPa), the exhaust valve to follow, only a sharp rise in pressure in the boiler deflated, used only relief exceeds 0.9MPa, and the exhaust process to be carried out slowly, prevention boiler due to loss of pressure and more violently again vaporized. ④ close the boiler water, water main gas valve. ⑤ open stop valve recirculation line, to ensure that the water supply pipe velocity convection heating surface (economizer) to prevent re-vaporization of the economizer. ⑥ The operation of the above operation, at the same time to pay the boiler to reduce the boiler water temperature and the furnace pressure. ⑦ After the boiler pressure is normal, i.e., opening the standby circulating pump, into the normal combustion. 2. Treatment failure or sudden loss of power boiler vaporization of power: ① immediately open the door, lift the coal chute slide gate to take pressure fire measures to reduce the oven temperature. ② Grate with the fastest speed in order in the shortest time to fire onto the slag tap. ③ the degree of treatment in the first case. Once a short time can not supply heating network system, antifreeze should take emergency measures. 3. Due to excessive heat boiler boiler vaporization process: ① the immediate closure of the drum, induced draft fan. ② immediately open the door, take measures to pressure the fire, lift the supply of coal chute slide gate, off of coal, while the grate into fast gear. ③ In the case confirmed the presence of water, the boiler can supply water to the boiler body, boiler out of the water while closing the main valve. ④ Open line stop valve recirculation pump to ensure water velocity convection heating surface of the pipe, to prevent the economizer again vaporized. ⑤ Open circulating pump with jog mode, jog each time less than 30 seconds, again less than one minute jog interval. Jog purpose is to reduce the boiler water temperature, while preventing a large amount of steam into the pipeline system. ⑥ back into place after the safety valve, circulating pump running, and then the normal burning stove. 4. Water boiler system run vaporization process due to water loss, loss of pressure caused by: ① immediately closed drum, induced draft fan. ② out of the water while closing the main valve and the boiler circulating pump. ③ take the same measures to cool the furnace tube described above. ④ Open stop valve recirculation line. ⑤ rely exhaust valve until the safety valve back into place. ⑥ until the boiler water temperature drops below 50 ℃, when the temperature of the furnace temperature less number 200 ℃, again within the boiler feed water, water course to be carried out slowly, to prevent harm to the boiler when the temperature is too large. ⑦ After processing leakage fault, the system time to the replenishment, and out of the water boiler always open the valve, and the circulating pump, and then normal combustion.

The method of adjusting the temperature of the superheated steam heating stove have? The method of adjusting the temperature of the superheated steam heating stove have? DC boiler steam temperature is mainly adjusted by adjusting the quantity of fuel to water. In actual operation, because the efficiency of boiler feed water and fuel heat enthalpy (depends on the water temperature) and the like will change, so the actual boiler operation to ensure the water-fuel ratio of the exact value is not easy. Coal-fired furnace will fluctuate because of the amount of coal and the amount of fuel due to the steam temperature. So, except DC boiler fuel to water ratio as the coarse adjustment means, but also must be used as a method of spray desuperheater means of fine-tuning adjustment. There is also some boiler flue gas recirculation, dampers and methods of the swing center of the flame as an auxiliary adjusting device.

In mid-June this year, Hebei Province issued a notice regarding the development of gas-fired boiler nitrogen oxides (referred to as NOx) governance, in order to further deepen the boiler pollution control, reduction of nitrogen oxide emissions, improving air quality, will gradually nitrogen oxides exceeded boiler discharged for investigation and control work, high nitrogen oxide emissions from the original (150mg / Nm3 or above) is reduced to 30mg / Nm3. City, Hebei Province is located in the Yili Dairy Co., Ltd. to respond positively to governance EPA gas boiler NOx reduction, and led the way, three of the company's existing 15 steam tons / hour (t / h) gas made in china coal fired steam boilers for low-nitrogen emissions transformation.

Main made in china coal fired steam boiler temperature abnormal phenomenon of how to do 1, main steam temperature anomalies alarm. 2, the rapid variation of the main steam temperature, a secondary damper frequently significantly reducing water operation. 3, starting superheat outlet steam separator above or below normal. 4, if the steam with water, the unit will water shock occurs. 1 reason, the fuel and water supply imbalance, the separator outlet temperature abnormality. 2, coal combustion conditions change or affect, such as excessive load lift; and pulverizing mill administration system abnormality stop; means automatically increase or decrease the failure rate is too large amount of wind and the like. 3, the central flame furnace changes, such as the bottom seal damage, W and inadequate flame downstroke. 4, the control failure by warm water, warm water flow rate reduction is abnormally reduced or increased. 5, feedwater temperature mutation. 6, does not match the wind coal. 7, the secondary combustion heating surface. 8, furnace coking or fouling seriously. 9, heating surface leakage squib. 10, flue gas damper opening degree is not normal. 11, coal sudden change occurred. 12, the uniformity of the powder feeding substantial change occurs. 1 process, failure caused by unit coordinated coal - water ratio should be immediately released coordinate offset, in accordance with the current load demand, with reference to the start of the steam superheat separator, and adjusting the amount of fuel corresponding to the amount of water, with one, two main desuperheating water rapidly steam temperature control in a normal range; when the coal - water ratio should avoid imbalance after coal and water while adjusting; when coal - water ratio is adjusted to further adjust the load after a relatively stable; contact maintenance processing timely. 2, when the water supply system fault condition occurs a significant disturbance furnace should pay attention and automatically coordinated working conditions, so as not to manual intervention, when not working properly coordinated and automated, should be manually adjusted, stable water flow, referring to separation according to the water flow steam superheat, the adjusted amount of fuel, with a secondary spray water rapidly controlling the main steam temperature within the normal range; contact maintenance processing timely. 3, due to rapid changes in load caused by the load change rate should be adjusted; load change caused due to protective operation or the like caused by heat load to be quickly adjusted to maintain the boiler pressure of the main steam stability. 4, by warm water automatic dysregulation, should be appropriate Save warm tone is switched to the manual may be an intermediate point of the feedwater control system be corrected for temperature if necessary, or the feedwater to switch control to manual control, due to lower lifting and lowering the load speed to prevent steam temperature, promptly contact a service process. 5, the boiler furnace cause severe fouling and coking of the main steam temperature anomalies can be corrected by an appropriate degree of superheat outlet steam separator start, adjust, and in a timely manner and the furnace heating surface sootblowing. When the platen superheater sootblowing or superheater outlet temperature is still above normal and a secondary reducing water damper fully open, to check the furnace and the combustion air distribution system is normal, the checking process to reduce still overtemperature unit load. 6, flue gas damper adjusted to an appropriate opening degree. 7, if the bottom seal after losing back to normal immediately. 8, to strengthen the turbine expansion, differential expansion, axial displacement of the shaft vibration and bearing temperature monitoring, if abnormal, the process according to the corresponding regulations. 9, after the above measures, if invalid, should immediately drop the load process. 10, in front of the main steam temperature main steam 50 ℃ drastically reduced within 10 minutes, should an emergency stop.

made in china coal fired steam boiler Related Information

China New PLC Control System Wood Pellet Steam

Boiler, Biomass, Hot Water Boiler manufacturer / supplier in China, offering New PLC Control System Wood Pellet Steam Generator Boiler, Industrial Biomass Wood Chips, Rice Husk Fired Water-Fire Tube Steam Boiler Generator 1-4t/Hr for Food Industry, Industrial Coal, Biomass, Wood Chips Fired Steam Generator Boiler 1-4t/Hr Food Industry and so on.

Get a Quote

China Water-Fire Tube Coal Fired Steam Boiler - China

China Water-Fire Tube Coal Fired Steam Boiler, Find details about China Boiler, Steam Boiler from Water-Fire Tube Coal Fired Steam Boiler - QINGDAO HAMMER INDUSTRIES CO., LTD.

Get a Quote

China Steam Boiler manufacturer, Hot Water Boiler,

Steam Boiler, Hot Water Boiler, Gas Boiler manufacturer / supplier in China, offering 3ton/Hr Three Pass Good Price Solid Fuel Steam Boiler, Wood Fired Hot Water Induction Horizontal Industrial Steam Boiler Price, Wood Chip Coal Fired Wet Back Industrial Steam or Hot Water Boiler and so on.

Get a Quote

China Vertical Coal Fired Small Steam Generator Price

China Vertical Coal Fired Small Steam Generator Price, Find details about China Small Boiler, Mini Boiler from Vertical Coal Fired Small Steam Generator Price - Henan Taiguo Boiler Manufacturing Co., Ltd.

Get a Quote

China Single Drum Coal Fired Water- Fire Tube Steam

China Single Drum Coal Fired Water- Fire Tube Steam Boiler, Find details about China Full-Automatic Feeding and Deslagging, Chain Grate from Single Drum Coal Fired Water- Fire Tube Steam Boiler - Nanning Miracle Import and Export Trading Co., Ltd.

Get a Quote

Biomass Fired Steam Boiler Made in China - China

Industial coal biomass fired boiler The DZL series quickly installed coal fired steam boiler is the most advanced water-fire tube boiler in Chinese market, This series boiler can be used in textile, food and package factory with high efficiency, small in size and long working life.

Get a Quote

Biomass Fired Steam Boiler Made in China - China

Industial coal biomass fired boiler The DZL series quickly installed coal fired steam boiler is the most advanced water-fire tube boiler in Chinese market, This series boiler can be used in textile, food and package factory with high efficiency, small in size and long working life.

Get a Quote

Wns Series Automatic Gas or Oil Fired Steam Boiler -

Wns Series Automatic Gas or Oil Fired Steam Boiler, Find Details about Gas Boiler, Oil Boiler from Wns Series Automatic Gas or Oil Fired Steam Boiler - Nanning Miracle Import and Export Trading Co., Ltd.

Get a Quote

china made coal fired steam boiler - toyotateamnoris.de

Our oil/gas fired boilers can be divided into SZS china made coal fired steam boiler and WNS china made coal fired steam boiler depending on the medium inside the tubes. With multiple pressure designs, the water tube boilers can meet the steam supply requirements of 2.5MPa or above. The fire tube boilers, on the contrary, are intended for use

Get a Quote

China Superior Quality and Efficiency Coal Fired Steam

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Superior Quality and Efficiency Coal Fired Steam Boiler Price, Add to Comparesharewaterproofing Materials HDPE Geomembrane Liners Smooth Surface, HDPE LDPE LLDPE Geomembrane Pool Pond Liner and so on.

Get a Quote

china made coal steam boiler - devlietoevers.nl

china made coal boiler - ffw-thaining.de. Coal Fired Steam Boiler. 2018-12-26 · The most important thing is that our boilers are all tailor-made.They are designed all depending on your business,including on the fuel,capacity,pressure and so on you need. 4.1 ton 2 ton 4 ton 6 ton coal boiler are package boiler,8 ton 10 ton and bigger capacity are assemble boiler Xihua County, Zhoukou, Henan

Get a Quote

steam boiler made in china

2018-7-5 · Boiler, Steam Boiler, Hot Water Boiler manufacturers / suppliers in China, offering 700 Kw Gas/Oil Fired Thermal Oil Heater, 1 T/H Made-in-China.com - China Boiler, Steam Boiler, Changzhou Shinmo International Trade Co., Ltd. Boiler, Steam Boiler, Gas Boiler manufacturers / suppliers in China, offering 1t/H Industrial Water Tube Coal

Get a Quote

Coal Fired Steam Boiler

2020-3-14 · 2.Single drum water tube and fire tube boiler. 3.Fuel coal,solid fuel. 4.1 ton 2 ton 4 ton 6 ton coal boiler are package boiler,8 ton 10 ton and bigger capacity are assemble boiler. 5.Working pressure:1.0Mpa 1.25Mpa 1.6Mpa. Then,here are the accessories and valves about the Coal Steam Boiler: Customer visit: Intimate tips for you here:

Get a Quote

China Coal Fired Steam Boiler (DZL, SZL) - China

Coal fired steam boiler Our coal fired boiler includes DZL type boiler, SZL type boiler. DZL boiler has steam boiler from 1t to 60t/h and hot water boiler from 0.7 to 42MW. Single drum, threaded line pipe, chain grate, fire tube, assembled boiler. SZL boiler has steam boiler from 2t to 20t/h and hot water boiler from 1.4 to14MW.

Get a Quote

China Environment Friendly Water Tube Steam Coal

Coal Boiler, Steam Boiler, Best Price Boiler manufacturer / supplier in China, offering Environment Friendly Water Tube Steam Coal Fired Boiler, 3ton/Hr Three Pass Good Price Solid Fuel Steam Boiler, Wood Fired Hot Water Induction Horizontal Industrial Steam Boiler Price and so on.

Get a Quote

Related Information

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!